Safety Guides

FISA Safety Guides are listed below and are all downloadable for printing direct. They are numbered in the same format as the previous AFAG Safety Guides.

Ban on tyres over 10 years old for heavy vehicles

From 1 February 2021 Construction and Use Regulations will not allow tyres aged over 10 years old to be used on the front steered axles of HGVs, buses, coaches or all single wheels fitted to a minibus (9 to 16 passenger seats). So, if used it will mean a dangerous fail at annual test and a prohibition.

If inspected at a DVSA enforcement check, tyres aged over 10 years old found on these positions will be considered dangerous and attract an ‘S’ marked immediate prohibition notice.

It will also be a requirement for the manufacturer’s date code to be legible on all tyres fitted to HGVs, trailers over 3.5 tonnes, buses, coaches and minibuses. If a tyre is a retread then the manufacturer date is taken from when the retread was carried out.

Tyres without a legible manufacture date code, fitted to the front steered axle of HGVs, buses, coaches or single wheels fitted to a minibus will fail the annual test.

If found at a DVSA enforcement check this would attract a delayed prohibition.

However, if there are also obvious signs of deterioration of the tyre the action will be increased to an ‘S’ marked immediate prohibition notice.

If the manufacturer date code is not legible on other wheel positions, this will also be an offence and a minor fail result will be recorded at annual test. This would not prevent the issue of a pass certificate but there would be an expectation that the tyre is replaced.

If the date code is not legible at an enforcement check an inspection notice would be issued and again, we would expect the tyre to be replaced.

Using tyres more than 10 years old on other wheel positions 

It’s the operator’s responsibility to make sure they have an adequate tyre management system in place and that they regularly consider the risks associated with using older tyres, even if the law permits.

Where tyres more than 10 years old are legally used on other wheel positions, their age should be recorded and a specific risk assessment is completed, that considers the distance, speed and loading conditions that the vehicle will operate under (for example, operating only in urban areas).

Driver responsibility 

In addition to the age or legibility of the code, consideration will be given to the visible deterioration of the tyre to decide whether the driver is culpable.​

We would expect the driver to identify obvious visible tyre deterioration, damage or wear on their walkaround checks.  ​

Owner-drivers will normally be considered culpable of tyre age or marking offence regardless of visible deterioration.

Reporting to the Traffic Commissioner

Some of you have asked if we’ll report drivers and operators to the Traffic Commissioner if we catch them using tyres more than 10 years old or without a legible manufacturer date code.

If an operator with a tyre more than 10 years old or without a date code, which attracts an ‘S’ marked prohibition notice initial  follow up will be with the operator. If the operator can’t show that they’re adequately managing their tyres, they may be referred to the Traffic Commissioner.

Print

Additional information

Aerial tree work guides from Arboricultural Association can be found here

A couple of AFAG guides can be found here

Bulk purchase of some of the FISA guides is available - please email technical@ukfisa.com for more detail.